BONDCERAM 1204 
MATERIAL SAFETY DATA SHEET

 Section I -- Product Identification

Manufacturer: Hottec Inc. Phone (860)887-5111

One Terminal Way

Norwich, CT 06360

Product Class: SOLVENT PRIMER 

HAZARD RATING 0à4

Trade Name : E1204 

Reactivity 0 low-extreme

Product Code: 2763060 

Health 2 Fire 3

C.A.S. # : N/AP

Section II - Hazardous Ingredients

* LISTED BY IARC AS PROBABLY CARCINOGENIC TO HUMANS

* LISTED BY NTP AS REASONABLY ANTICIPATED TO BE CARCINOGENIC

* LISTED BY OSHA AS A CARCINOGEN

***All ingredients in this product are listed in the T.S.C.A. Inventory.

Section III -- Physical Data

Boiling Range: 175-180 °F Vapor Density: Heavier than Air

Evap. Rate: Faster than n-Butyl Acetate Liquid Density: Heavier than water

Volatiles vol %60 Weight %49 Weight per gallon: 8.47 pounds

Spec. Gravity: 1.01681

Appearance: Thin amber liquid alcohol odor

V.O.C.: 512 G/L

Section IV -- Fire and Explosion Hazard Data

Flammability Class: 1B Flash Point: 20 F TCC LEL: 2.00%UEL: 12.70%

EXTINGUISHING MEDIA:

Water Fog, Carbon Dioxide, Foam, Dry Chemical

Section IV -- Fire and Explosion Hazard Data (contd.)

ÄSPECIAL FIREFIGHTING PRODEDURES:

DO NOT ENTER CONFINED FIRE SPACE WITHOUT PROPER PROTECTIVE EQUIPMENT INCLUDING NIOSH APPROVED SELF CONTAINED BREATHING APPARATUS.

ÅUNUSUAL FIRE & EXPLOSION HAZARDS:

VAPORS MAY BUILD UP IN POORLY VENTILATED AREAS AND BE IGNITED, CAUSING FLASH FIRES OR EXPLOSIONS. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL ALONG GROUND OR FLOOR TO SOURCE OF IGNITION, CAUSING FLASH FIRES OR EXPLOSIONS.

Section V -- Health Hazard Data

ÅPERMISSIBLE EXPOSURE LEVEL:

SEE SECTION II

ÅEFFECTS OF OVEREXPOSURE:

INHALLATION: NOSE AND THROAT IRRITATION, HEADACHE,

NAUSEA, LOSS OF COORDINATION, DIZZINESS,

UNCONSCIOUSNESS, AND EVEN ASPHYXIATION.

SKIN CONTACT: MAY CAUSE DEFATTING OR DERMATITIS.

EYE CONTACT : MAY CAUSE IRRITATION, OR CORNEAL CLOUDING.

INGESTION : ASPIRATION INTO LUNGS MAY CAUSE CHEMICAL

PNEUMONITIS.

CHRONIC EFFECTS

OF OVER EXPOSURE: MAY CAUSE DEFATTING AND DERMATITIS.

MAY CUASE KIDNEY OR LIVER DAMAGE.

ÅNOTICE: REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED

OCCUPATIONAL OVER-EXPOSURE TO SOLVENTS WITH

PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.

INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING

AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.

OVER EXPOSURE HAS BEEN SUGGESTED AS A CUASE OF FOLLOWING EFFECTS; LIVER ABNORMALITIES, KIDNEY DAMAGE, CENTRAL NERVOUS SYSTEM DAMAGE

MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: NONE KNOWN.

ÅFIRST AIDE

INHALATION: REMOVE TO FRESH AIR, IF NOT BREATHING, GIVE

ARTIFICIAL RESPIRATION, PREFERABLY MOUTH TO MOUTH, IF

BREATHING DIFFICULT GIVE OXYGEN, CALL A PHYSICIAN AT ONCE.

SKIN CONTACT: REMOVE CONTAMINATED CLOTHING AND

LAUNDER BEFORE REUSE. WASH AFFECTED AREA WITH PLENTY

OF SOAP AND WATER.

EYE CONTACT: FLUSH WITH PLENTY OF WATER FOR AT LEAST

15 MIN (hold eye lids open) LONGER IF THERE IS INDICATION OF

RESIDUAL MATERIAL IN EYE.

INGESTION: DO NOT INDUCE VOMITING. CALL A PHYSICIAN

IMMEDIATELY

Section VI -- Reactivity Data

Stability: [ ] unstable [x] stable

Hazardous Polymerization: [ ] may occur [x] will not occur

-Incompatibility:

Strong oxidizing agents.

-Conditions to avoid:

See above.

-Hazardous Decomposition Products:

Carbon Dioxide, Carbon Monoxide, Smoke, Aliphatics, and others.

Section VII -- Spill or Leak Procedures

-Steps to be taken in case material is released or spilled

Eliminate all ignition sources, provide adequate ventilation, avoid breathing

Vapors, avoid eye and skin contact. Wipe up with rags, paper or other absorbent

Material. Place in suitable closed containers for disposal.

-Waste Disposal Method

This material is discarded, is hazardous and must be properly stored, trans-

Ported, and disposed of in accordance with applicable local, state, and federal

Regulations.

Section VIII -- Special Protection Information

-Respiratory Protection:

For air contaminants above TLV or permissible limits use NIOSH approved

Respirator for organic vapors.

-Ventilation:

Local exhaust to keep vapors below TLV or permissible limits.

-Protective Gloves:

Impervious

-Eye Protection:

Chemical Goggles

-Other Protective Equipment:

Eye wash and safety shower

Section IX -- Special Precautions

-Precautions to be taken in handling and storing:

Use only in a well ventilated area. Eliminate all sources of ignition such as sparks, flames, and non-explosion proof devices. Avoid prolonged or repeated skin contact or breathing of vapors. For industrial use only, keep out of the reach of children. Store in tightly closed containers, in a cool dry place, away form all sources of ignition and heat. Large containers should be grounded and interconnected to prevent static build up during transfer operations. Empty containers of this material may be hazardous since they may contain residual liquid, vapors, or dust.

________________________________________________________________________

Section IX -- Special Precautions contd.

-Other Precautions:

In addition to any listed precautions, you should consult your occupational safety and health specialist to insure that the handling procedures will be adequate and in compliance with applicable laws and regulations.

-DISCLAIMER OF LIABILITY: The Information contained here in is based on data taken from sources believed to be both current and reliable at the time of publication. Sovereign engineered adhesives, L.L.C., however makes no warranties express or implied , as to its accuracy and assumes no liability arising from its use by others. Compliance with all applicable federal, state and local laws and regulations remains the responsibility of the users.

Section X -- Additional Regulatory Information

-Sara Title III Section 313

This product contains the following toxic chemicals subject to the reporting requirements of section 313 of the Emergency Planning and Community Right to Know Act of 1986 and of 40 CFR 372:

-Prop 65 (Carcinogen):

WARNING: This product contains a chemical known to the state of California to cause cancer.

Product may contain trace amounts of California proposition 65 listed chemicals.

-Prop 65 (Teratogen): WARNING This product contains a chemical known to the state of California to cause birth defects or other reproductive harm.

-Prop 65 (Both Teratogen and Carcinogen): WARNING This product may contain a chemical known to the state of California to cause cancer or birth defects or other reproductive harm.